火星塞問題 - 機車

By Isabella
at 2019-07-21T23:53
at 2019-07-21T23:53
Table of Contents
: : 2. 如果選擇每6000換,需要上防卡劑嗎?
: : 會選擇上防卡劑的人我看都是高里程才會上,如果常常換就不需要特別上防卡劑了,並且
: : NG
: : K官方建議說不用特別上任何潤滑劑,所以到底是要上還是不用上?
: 火星塞廠商會建議 不用特別上任何潤滑劑 是因為
: 上了,鎖緊扭力會被放大,比如說 標準扭力是 10NM
: 你上了潤滑,扭力板手鎖 10NM 實際上可能是 12NM
: 個人建議還是 上,不過扭力值要放小一點
查閱NGK跟Denso的官方網站,都不建議使用任何潤滑油安裝
同時,使用潤滑劑也不會使扭力放大,這樣靜力學不平衡
但如果是形容 "如同扭力放大般的效果",那應該沒錯
官方不推薦使用任何潤滑劑的原因如下 (Denso官網)
If you apply grease or another screw thread lubricant to the threaded part of
the plug, you are liable to tighten the plug to an excessive degree,
impairing the integrity of the seal, even if you apply no more than the
recommended torque. For this reason, do not coat the plug with screw thread
lubricant.
如果使用潤滑油在牙處,會造成過多的 "角度",使得密封墊片的效果下降
原因在於,當扭力扳手施加力矩在螺絲時會轉化成三種力
(1)拉伸螺絲本身的力 + (2)克服螺紋摩擦的力 + (3)與金屬平面接觸的摩擦力
其中第三項會影響密封墊片的效果
三種力表現的分布如下圖
https://upload.cc/i1/2019/07/21/IekpW6.png
如果在螺牙的部分上油,那第二項"螺紋摩擦力"就會下降
於是火星塞會因為扭力未到設定所以可以繼續往下鎖,進而造成密封墊片變形而效果下降
同時火星塞最後鎖緊的角度也會與預設不同
但最終仍然是設定的扭力值,只是更多負擔由第三項承擔
https://upload.cc/i1/2019/07/21/H8QiqI.png
--
: : 會選擇上防卡劑的人我看都是高里程才會上,如果常常換就不需要特別上防卡劑了,並且
: : NG
: : K官方建議說不用特別上任何潤滑劑,所以到底是要上還是不用上?
: 火星塞廠商會建議 不用特別上任何潤滑劑 是因為
: 上了,鎖緊扭力會被放大,比如說 標準扭力是 10NM
: 你上了潤滑,扭力板手鎖 10NM 實際上可能是 12NM
: 個人建議還是 上,不過扭力值要放小一點
查閱NGK跟Denso的官方網站,都不建議使用任何潤滑油安裝
同時,使用潤滑劑也不會使扭力放大,這樣靜力學不平衡
但如果是形容 "如同扭力放大般的效果",那應該沒錯
官方不推薦使用任何潤滑劑的原因如下 (Denso官網)
If you apply grease or another screw thread lubricant to the threaded part of
the plug, you are liable to tighten the plug to an excessive degree,
impairing the integrity of the seal, even if you apply no more than the
recommended torque. For this reason, do not coat the plug with screw thread
lubricant.
如果使用潤滑油在牙處,會造成過多的 "角度",使得密封墊片的效果下降
原因在於,當扭力扳手施加力矩在螺絲時會轉化成三種力
(1)拉伸螺絲本身的力 + (2)克服螺紋摩擦的力 + (3)與金屬平面接觸的摩擦力
其中第三項會影響密封墊片的效果
三種力表現的分布如下圖
https://upload.cc/i1/2019/07/21/IekpW6.png

如果在螺牙的部分上油,那第二項"螺紋摩擦力"就會下降
於是火星塞會因為扭力未到設定所以可以繼續往下鎖,進而造成密封墊片變形而效果下降
同時火星塞最後鎖緊的角度也會與預設不同
但最終仍然是設定的扭力值,只是更多負擔由第三項承擔
https://upload.cc/i1/2019/07/21/H8QiqI.png

--
Tags:
機車
All Comments

By Rachel
at 2019-07-23T11:06
at 2019-07-23T11:06

By Kumar
at 2019-07-27T12:24
at 2019-07-27T12:24

By Bethany
at 2019-07-31T12:08
at 2019-07-31T12:08

By William
at 2019-08-02T03:13
at 2019-08-02T03:13

By Hazel
at 2019-08-02T16:02
at 2019-08-02T16:02
在螺牙處上油嗎?

By Brianna
at 2019-08-03T19:19
at 2019-08-03T19:19
的種類 旨在避免高溫後的卡死而非潤滑 而grease一類的sc
rew thread lubricant 只是一種油膏 潤滑螺紋以減少鎖入
時的磨損 與幫助達到預期的鎖緊扭力 它是撐不過超過250
℃火星塞的溫度 與high temperature, anti-seize & thre
ad lubricant目的不同。再者 火星塞並不是具螺母的固定
用螺絲 它結構比較像是靠前端墊圈形變密封的調整螺絲 和
你的圖完全是不同的東西 不可以張飛打岳飛。最後 我隨便
搜尋高溫防卡膏的TDS 其中一種典型的應用就是spark plug
threads installed into aluminum heads。我覺得可以再
提出更多資料討論討論。
https://i.imgur.com/PEm4tE0.png

By David
at 2019-08-07T09:26
at 2019-08-07T09:26

By Zanna
at 2019-08-10T23:44
at 2019-08-10T23:44

By Ina
at 2019-08-14T19:43
at 2019-08-14T19:43

By Robert
at 2019-08-15T00:29
at 2019-08-15T00:29

By Kumar
at 2019-08-15T03:00
at 2019-08-15T03:00

By Rebecca
at 2019-08-15T10:28
at 2019-08-15T10:28

By Jessica
at 2019-08-16T02:56
at 2019-08-16T02:56

By Hardy
at 2019-08-18T19:52
at 2019-08-18T19:52

By Ida
at 2019-08-21T21:08
at 2019-08-21T21:08

By Tracy
at 2019-08-22T11:38
at 2019-08-22T11:38
你沒看錯 就是三千到五千

By Odelette
at 2019-08-22T16:36
at 2019-08-22T16:36

By Jessica
at 2019-08-27T04:18
at 2019-08-27T04:18

By Hedda
at 2019-08-29T11:01
at 2019-08-29T11:01

By Heather
at 2019-09-01T19:00
at 2019-09-01T19:00

By Dinah
at 2019-09-05T18:43
at 2019-09-05T18:43
過只能上前兩牙而已
目的也是防卡

By Tom
at 2019-09-07T13:53
at 2019-09-07T13:53

By Susan
at 2019-09-09T17:27
at 2019-09-09T17:27
普通便宜的火星塞是需要上防卡膏的 而NGK受惠於鍍鋅塗層

By Agnes
at 2019-09-10T19:20
at 2019-09-10T19:20
還是塗一點在螺紋中段 並降些鎖緊扭力值(約10%)
畢竟真卡住了你也不可能請NGK負責

By Damian
at 2019-09-15T10:03
at 2019-09-15T10:03

By Susan
at 2019-09-18T22:22
at 2019-09-18T22:22

By Ivy
at 2019-09-22T03:07
at 2019-09-22T03:07

By Brianna
at 2019-09-24T10:07
at 2019-09-24T10:07

By Candice
at 2019-09-26T07:29
at 2019-09-26T07:29

By Quintina
at 2019-09-29T11:27
at 2019-09-29T11:27

By Hamiltion
at 2019-10-03T07:34
at 2019-10-03T07:34

By Rae
at 2019-10-05T19:25
at 2019-10-05T19:25
Related Posts
韓國重機追撞, 驚險過程全都錄。

By Andy
at 2019-07-21T20:21
at 2019-07-21T20:21
請問swish後照鏡改裝建議

By Edwina
at 2019-07-21T18:45
at 2019-07-21T18:45
裝菜籃載重能改善裝漢堡浮頭嗎?

By Gary
at 2019-07-21T15:07
at 2019-07-21T15:07
大潤發購入美孚Super5000

By Dinah
at 2019-07-21T14:50
at 2019-07-21T14:50
SYM Maxsym 400TL預告年底登場!

By Tristan Cohan
at 2019-07-21T11:59
at 2019-07-21T11:59